Study on the emergency tent by Shunya Susuki (01June, 2008) |
|
A cheap tent made of 1.8m by 1.8m plastic leisure sheets that I bought at a 100 yen shop | |
A piece of drawing for the side figure of the tent (07 June, 2008) | |
Confirmation of the tent's shape Four pieces of A-4 size recycled paper are cut in the shape of the above diagram and put together as in the left photograph. (14 June, 2008) |
|
Four pieces of the 1.8m by 1.8m plastic sheet folded at the center are collated with the full-scale CAD drawing. (12 July, 2008) | |
The four sheets are cut to the full-scale CAD drawing and are connected with each other by 15mm wide double-stick tape. The photograph below shows how it looks.
(12 July, 2008)
|
|
I made the frame for the tent (31 August, 2008) I cut a half dozen young bamboos one month ago and let it dry to use it as the frame. However, because of the strength problem, I decided at the last minute to use some gardening materials made of thin iron pipes instead. I cut five 1.8m iron pipes of 8mm in diameter into six and bent them along the curve of my tent as shown in the left photograph. I used an aluminum pipe of 1cm diameter as joints. |
|
I assembled the tent and its frames in my garden(31 August, 2008) I will make further studies on frame curve adjustment and the strength of the frames in future. |
|
I assembled the tent and its frames in my garden again.(07 September, 2008) I readjusted the frames and covered them with the tent sheet. |
|
I confirmed its shape. (07 September, 2008) |
|
I completed installing two windows in the tent. (22 September 2008) These windows have an insect screen. | |
I completed installing a door in the tent.(13 October 2008) The door has enough folds at its both sides so that no rain or insects can enter the tent when it is open. |
|
I completed installing the floor seat in the tent.(13 October 2008) The floor is made of 1.8m by 1.8m sheet with a different color. This simple tent is completed with only five pieces of plastic sheet costing 100 yen each. |
|
I assembled the tent.(13 October 2008) Its windows and door are closed. Its frames are stuck into the ground. |
|
Its windows and door are opened. |
|
Its windows are opened and its door is closed. |
|
The inside: The floor area is a square with one side being about 1.8 meters in length. The corner of the wall and the window on the other side |
|
The inside:The window and the door on the other side The tent is tied to its frames with strings at 4 points per each frame. |
|
The inside: The height of the window is just good. |
|
The inside: The window is closed. |
|
The inside: The joint at the ceiling |